Cleaning a lawn mower carburetor

In addition to cleaning the carburetor, many engine performance problems can be linked to maintenance issues such as stale fuel, dirty air filter, fouled spark plug, and deteriorated oil. Watch how to complete a full tune up on your lawn mower to help it run perfectly. If so, your problem is most likely a corroded or gummed-up carburetor.

Small engine repair shops earn about percent of their revenue by cleaning or replacing carburetors that are sidelined by old gas. Look at your lawn mower carburetor. Before you rip into the sucker, take a minute to confirm that the carburetor’s the problem. The carburetor can be at the root of problems with a lawn mower. Checking to be sure this part is not loose or corroded is a good first step.

Cleaning and adjusting the carburetor is also a simple way to troubleshoot problems that it may be causing and get your lawn mower working properly again. Cleaning the carburetor of a lawn mower is an important part of maintenance. This article will walk you through the steps of removing your carburetor , cleaning it, replacing any parts and putting it all back together. Find carburetor repair kits and any lawn mower parts or maintenance by visiting our lawn equipment parts page.

Place the lawn mower on a level surface.

Remove the air filter housing that sits over the carburetor. Before you get starte you may want to purchase an O-ring if your lawn mower is ol as the O-ring in the carburetor tank may be worn. Tecumseh engine in a Toro lawnmower will help keep your engine performing at its best. There are small holes in a carburetor that air and fuel must.

After storing your lawn mower for a season, it is very likely that the leftover gas in the carburetor is gummed up and will need to be cleaned out before the engine will run properly. While it’s relatively easy and straightforward to service a Honda carburetor in today’s most popular lawn mower models, the kind of debris and damage that can be sustained by this equipment sometimes necessitates a full replacement. Works with Car, Lawn Mower to Increase Power, Efficiency and Economy Boosting Stabilizer. Cleaning your small engine’s carburetor isn’t terribly daunting, but I recommend that you have the correct service manual for your engine and a carburetor rebuild kit on hand before tackling it. Some lawn mower gas tanks have a filter in the bottom where the out let is.

The filter can block as can the out let pipe, causing fuel starvation. Best Answer: What you described sounds like the carburetor is still dirty. You will want to remove the carburetor and thoroughly clean it. I have provided a link to how to clean the carburetor below.

This DIY riding mower repair guide gives step-by-step instructions for rebuilding the carburetor on a riding lawn mower. A properly operating carburetor is essential to a smooth running engine that is easy to start. More than of all of our repairs in our lawn mower business are due to this same issue. You most likely have dirt, gum, varnish. Each of these engines includes carburetors that need occasional cleaning to keep them running and starting correctly.

Lawn mowers that do not start easily, start and immediately die or idle and run roughly point to a dirty carburetor that needs attention. I have a Kohler lawn mower that ran well for the first five minutes and then cut out. I bought a new coil and again it ran flawlessly for the first five minutes and then died. After receiving this shipment, I put the new carburetor onto the lawn mower along with the included air filter. If your engine is hesitating, stumbling, stalling, letting out black smoke, or has a hard time starting you may want to consider rebuilding your carburetor.

Find great deals on eBay for lawn mower carburetor jet cleaning tool. Carburetors can wear out for multiple reasons.